________________________________________________________________________________
JD LA105 Engine Problems
Engine not starting
Empty fuel tank - Add gasoline.
Improper fuel grade - Use correct gasoline grade.
Old gas - Drain fuel and replace with fresh fuel.
Dirty fuel lines - Inspect and clean.
Faulty spark plug wire - Inspect and replace if required.
Spark plug damaged - Spark plugs need to be replaced.
Dirty fuel filter - Change fuel filter.
Faulty safety switch - Change damaged switch.
Carburetor problems - Carburetor diagnostics required.
Inspect and adjust throttle cable. Compression problems.
Engine hard starting
Spark plug fail - Test spark and replace as required.
Wrong carburetor adjustment - Adjusting carburetor correctly.
Dirt in fuel lines - Clean fuel system components.
Throttle cable worn - Install new throttle cable.
Stale or incorrect fuel - Drain and add proper gasoline.
Loose or corroded electrical connections - Inspect and change wires if required.
Failing starter - Check starter, repair or replace.
Rough running engine
Plugged cooling fins - Clean cooling fins.
Loose electrical contacts - Check and replace damaged connections.
Ignition adjust incorrect - Check ignition system and adjust as required.
Choke cable sticks - Check and repair.
Air cleaner dirty - Clean or change air filter.
Engine misses under load
Spark plug worn out - Inspect spark plug wire.
Carburetor problems - Test and repair.
Ignition coil air gap incorrect - Check and adjust ignition coil air gap.
Engine overheating
Engine runs under excessive load - Reduce loads.
Cooling fins or air inlet plugged - Clean and wash dirty components.
Too little or too much oil - Add or drain oil.
Poor quality oil - Change oil.
Inspect crankshaft to main bearing clearance.
Fast idle speed - Adjust fast idle.
Engine does not idle
Poor spark plug contact - Adjust spark plug gap.
Spark plug failed - Test spark and replace as required.
John Deere LA105 Engine knocking
Stale gasoline - Use correct gasoline.
Excessive engine load - Reduce loads.
Oil level low - Add engine oil.
Low engine speed - Adjust the required speed.
piston rings or cylinder bore damaged - Replace damaged parts.
Inspect for engine overheats from clogged cooling fins.
Inspect and adjusting crankshaft end play.
Checking for wear crankshaft or camshaft bearings.
Engine back-fire
Checking spark plug.
Adjust or replace throttle.
Check and adjust carburetor.
Check and adjust ignition coil air gap.
Check inlet and outlet valves.
Test valve clearance, adjusting if necessary.
Checking flywheel key.
Loss of power
Engine temperature too high - Air cleaner element plugged.
Engine oil overfilled - Excess oil needs to be drained.
Defective fuel pump - Testing fuel pump output.
Governor not work - Inspect and repair governor.
Check carburetor float adjustment.
Checking engine compression.
Excessive fuel consumption
Choke doesn't open well - Replace choke cable.
Carburetor malfunction - Adjust or repair carburetor.
Black exhaust smoke
Air cleaner is dirty or oiled - Check and clean.
Throttle is partially engaged - Inspect and adjust throttle.
Check and adjust carburetor float level.
John Deere LA105 Electrical System Troubleshooting
Starter does not run
Main fuse malfunction - Install new fuse.
Terminals are severely corroded and heat up - Inspect and clean contacts.
Battery not charged - Charge the battery.
Ignition lock problems - Replace switch.
Damaged starter - Change the starter.
Electrical wires are damaged - Connect wires.
Battery doesn't charge
One or more battery cells dead - Change the battery.
Poor contact between cable and battery pole - Replace or clean cable.
Lighting does not function
Connection/disconnection level in wrong position.
Loose or burned out bulb.
Wiring short circuit.
JD LA105 Machine Problems
The machine vibrates
Equipment drive belts worn out - Check and replace worn belt.
Traction drive belt worn - Installing new driven belt.
Drive sheaves malfunction - Replace if necessary.
Unbalancing or bending of blades - Balance the blades or replace.
Machine does not move while engine is running
Parking brake locked - Unlock park brake.
Bypass valve lever in the push position - Disengage the bypass valve lever.
Loose lawnmower blades - Fasten the blades securely.
Improper blade balance - Balance the blades correctly.
Lack of oil in transmission - Pour oil as required.
John Deere LA105 Lawn Mower Troubleshooting
Discharge Chute Plugged
Travel speed too fast - Operate the mower at low speed.
Grass too long - try operating a short cutting height.
Grass too wet - Do not mow when grass is wet.
Engine runs at low revs - Open throttle fully.
Restricted air flow - Check engine rpm.
Mower deck set to low cutting - Adjust cutting settings.
Belt is loose - Fit belt correctly.
Uncut grass during operation
Debris in mower deck - Check cutting deck and clean if necessary.
Excessive blade wear - Sharpen the blade or install a new one.
Mower deck low - Leveling the mower deck.
Bagger too full - Empty the grass bag.
Ground speed too fast - Choose recommended speed.
Belt slips
Debris in pulleys - Clean or replace.
Belt is loose - Inspect and replace worn belt.
Belt tension is incorrect - Correct belt tension.
The lawn mower vibrates excessively
Mower deck clogged or in sheaves - Clean deck and pulley from debris.
Belt or sheaves faulty - Change damaged parts.
Misaligned belt or pulley - Check and adjust.
No blade balance adjustment - Blades need balancing.
Blade strips grass
Cutting height too low - Raise cutting height.
Mower wheel height incorrect - Check the wheel heights.
Tires inflated insufficient - Increase tire pressure.
Faster mower blade speeds - Blade speed required.
Blades are bent - Remove bent blade and install new one.
Uneven Cut
Mower deck low - Deck leveling required.
Tire pressure uneven - Increase tire pressure.
Wheels not positioned correctly - Check the wheel heights.
Ground speed too fast - Use slower speed.
Mower blades dull - Inspect and fit new blade if required.
________________________________________________________________________________
- ALL JD MODELS
- John Deere L130 Troubleshooting
- John Deere LX176 Troubleshooting
- John Deere LX178 Troubleshooting
________________________________________________________________________________
________________________________________________________________________________________
LAWN TRACTORS
FARM TRACTORS
MAINTENANCE
INSTRUCTIONS
PROBLEMS
________________________________________________________________________________________
JOHN DEERE LAWN TRACTORS SPECIFICATIONS |
X350
X380
X500
X590
X700
________________________________________________________________________________________
D130
D160
325
335
345
________________________________________________________________________________________
E140
G100
LT150
LX280
________________________________________________________________________________________
________________________________________________________________________________________
316
318
420
425
445
________________________________________________________________________________________
L108 Automatic
L120 Automatic
LA110 Automatic
LA120 Automatic
LA150 Automatic
________________________________________________________________________________________
LT155
LT160 Automatic
LT180 Automatic
LTR180
X165
________________________________________________________________________________________
E100
E120
E150
LTR166
X105 Automatic
________________________________________________________________________________________
LA135
LA165
LX277
LX288
LX255
________________________________________________________________________________________
X738
X740
X748
X749
X950R
________________________________________________________________________________________
S240
GT235
G110 Automatic
GX335
GX85
________________________________________________________________________________________
LA105
X300
X304
X310
X110 Automatic
________________________________________________________________________________________
X146R
X360
X155R
X140 Automatic
1025R
________________________________________________________________________________________
ENGINES FOR JOHN DEERE LAWN TRACTORS |
Kawasaki FB460V
Kawasaki FC420V
Kawasaki FC540V
Kawasaki FD501V
Kawasaki FD590V
________________________________________________________________________________________
Kawasaki FD620D
Kawasaki FH500V
Kawasaki FH580V
Kawasaki FH601V
Kawasaki FH661V
________________________________________________________________________________________
Kawasaki FS600V
Kawasaki FS651V
Kohler CV12.5
Kohler CV13S
Kohler CV14S
________________________________________________________________________________________
Kohler CV16S
Kohler CV15S
Kohler CV460S
Kohler CV491
Kohler CV730S
________________________________________________________________________________________
Kohler K161
Kohler K241QS
Kohler K301AQS
Kohler K321AS
Kohler K341AQS
________________________________________________________________________________________
Kolher KT17QS
Onan B43G
Onan B48G
Onan P218G
Onan P220G
________________________________________________________________________________________
JOHN DEERE TRACTORS ATTACHMENTS | ||||
420 | 430 | 455 | 790 | 990 |
X300 | X320 | X330 | X350 | X475 |
X485 | X500 | X540 | X570 | X590 |
X700 | X720 | X738 | X758 | 1023E |
2025R | 2210 | 2520 | 3025E | 3032E |
3038E | 3038R | 3039R | 3046R | 3203 |
3320 | 3520 | 4052R | 4066R | 4100 |
4105 | 4115 | 4200 | 4310 | 4320 |
4400 | 4410 | 4520 | 4600 | 4720 |
________________________________________________________________________________________
JOHN DEERE FRONT END LOADERS |
120R Loader
D120 Loader
H120 Loader
45 Loader
200CX Loader
________________________________________________________________________________________
D160 Loader
D170 Loader
H160 Loader
H165 Loader
H240 Loader
________________________________________________________________________________________
210 Loader
220R Loader
300E Loader
300X Loader
300CX Loader
________________________________________________________________________________________
300 Loader
300R Loader
320R Loader
400E Loader
410 Loader
________________________________________________________________________________________
JD TRACTORS TROUBLESHOOTING | ||||
2640 | 3040 | 3310 | 3650 | 4100 |
5050D | 5090R | 5410 | 6105R | 7200R |
E130 | L111 | LA110 | LT155 | X300R |
________________________________________________________________________________________
JOHN DEERE FARM TRACTORS SPECIFICATIONS |
2520
3005
3720
3033R
5039D
________________________________________________________________________________________
3036E
2038R
3038R
4049M
4100
________________________________________________________________________________________
4510
5045D
5050E
5060E
5078E
________________________________________________________________________________________
5065M
5055D
5115R
5105M
6110R
________________________________________________________________________________________